技术要求：

1、安装方式：挂壁式。

2、外形尺寸：550（高）×400（宽）×204（厚）（mm）

3、防护等级：IP44防溅式；

4、工作电压：18V~36V；

5、最大输出电流：15A

6、正常工作条件：

Δ环境温度-25_70℃；

Δ相对湿度：≤98%RH；　

Δ大气压力：86kpa~106kpa。　

Δ振动：2~25Hz时振幅为±1.6mm;13.2~80Hz;加速度±40a/s2

Δ有船舶正常营运所产生的振动和冲击的场所。　

7、箱体应符合IP44的规定，能承受任何方向的溅水而无有害影响。

8、通讯方式：RS485，CAN总线。

9、控制箱采用7寸彩色液晶屏显示发动机的转速、油压、水温、油温，以及电瓶电压，发动机运行时间，当发生超速预警、油压低、水温高、油温高电瓶电压时，控制箱发出声光报警提示，当发生超速停机、油压过低、水温过高时，控制箱发出声光报警并使发动机紧急停机动作。

10、控制箱面板上设置有：启动按键、消音、复位、自检按钮、停机按键、转速调节旋钮、电源开关、本地/遥控/自动、怠速/额定。

11、控制箱箱内预留有：超速报警延伸、油压低报警延伸、水温高报警延伸、油温高报警延伸、电源故障报警延伸、综合报警、运行信号延伸，转速微调、紧急停机输入，自启动输入、自停机输入接口。

12、对外留有一路RS485通讯接口以及一路备用电源输入接口。

13、控制箱有三次启动失败报警功能，三次自启动时间顺序：启动时间7秒，间隔时间为8秒，三次启动时间应为45秒内完成；当机组在自动状态时，机组检测到主电源故障（船舶主配电板提供的无源、常开触点，闭合时工作），机组自动完成下列动作：启动、升速、发出允许合闸信号（无源、常开触点，闭合时工作），从机组检测到主电源故障信号到输出允许合闸信号的时间不大于45秒。当机组检测到主电源恢复正常后，机组自动完成下列动作：发出分闸信号、降速、冷机运转120秒后停机。

14、主要特点：

①控制器8607拥有19路输入，19路输出，3路电压型，3路电流型，4路电阻型模拟量口，可根据应用场景选择不同的配置，自定义显示界面，通用性强。

②ECU故障码可以自动翻译成中文。

③电控机组，当ECU不带下垂功能，控制器可弥补ECU，实现下垂功能，解决船上并机问题。

technical requirement:

1. Installationmethod:Wall mounted.

2. Externaldimensions: 550 (H) x 400 (W) x 204 (T) (mm)

3. Protection level: IP44 splash-prooftype;

4. Operating voltage: 18V~36V;

5. Maximum output current: 15A

6. Normal working conditions:

Ambient temperature-25_70℃;

Relative humidity: 98%RH;

Atmospheric pressure: 86kpa~106kpa.

Vibration: 2~25Hz amplitude is ± 1.6mm; 13.2~80Hz; acceleration is ± 40a / s2

Places where vibration and impact arisefrom the normal operation of the ship.

7. The box shall comply with the provisionsof IP44 and can withstand the splashing water in any direction without harmfuleffects.

8. Communication mode: RS485, CAN bus.

9. The control box adopts 7-inch color LCDscreen shows the engine speed, oil pressure, water temperature, oiltemperature, battery voltage, engine running time, when overspeed warning, lowoil pressure, water temperature, oil temperature battery voltage, the controlbox sound and light alarm prompt, when overspeed shutdown, low oil pressure,water temperature, the control box alarm and make the engine emergencyshutdown.

10. The control box panel has: startbutton, noise elimination, reset, self-check button, stop button, speedadjustment knob, power switch, local / remote control / automatic, idle /rating.

11. The control box includes: overspeedalarm, oil pressure alarm, high water temperature alarm, oil temperature alarm,power fault alarm, comprehensive alarm, operation signal extension, speed finetuning, emergency stop input, self-start input, self-stop input interface.

12. There is an external road RS485communication interface and a road backup power input interface.

13.The control box has three failed startalarm functions, and the sequence of the three self start times is: start timeof 7 seconds, interval time of 8 seconds, and the three start times should becompleted within 45 seconds; When the unit is in automatic mode, it detects afault in the main power supply (passive and normally open contacts provided bythe ship's main distribution board, working when closed), and the unitautomatically completes the following actions: start, speed up, and issue anallowable closing signal (passive and normally open contacts, working whenclosed). The time from the detection of the main power supply fault signal bythe unit to the output of the allowable closing signal shall not exceed 45seconds. When the unit detects that the main power supply has returned tonormal, it automatically completes the following actions: issuing a tripsignal, reducing speed, and stopping the chiller after running for 120 seconds.

14. Main features:

① Controller 8607 has 19 inputs, 19 outputs, 3 voltage type, 3current type, and 4 resistance type analog ports.Different configurations canbe selected according to the application scenario, and the display interfacecan be customized, making it highly versatile

② ECU fault codes can be automatically translated into Chinese

③ Electronic control unit, when the ECU does not have droop function,the controller can compensate for the ECU, achieve droop function, and solvethe problem of parallel operation on board.

孚创动力

孚创动力